| Title |
Use of Chitosan as Copper Binder in the Continuous Electrochemical Reduction of CO2 to Ethylene in Alkaline Medium |
| ID_Doc |
14423 |
| Authors |
Marcos-Madrazo, A; Casado-Coterillo, C; Iniesta, J; Irabien, A |
| Title |
Use of Chitosan as Copper Binder in the Continuous Electrochemical Reduction of CO2 to Ethylene in Alkaline Medium |
| Year |
2022 |
| Published |
Membranes, 12, 8 |
| DOI |
10.3390/membranes12080783 |
| Abstract |
This work explores the potential of novel renewable materials in electrode fabrication for the electrochemical conversion of carbon dioxide (CO2) to ethylene in alkaline media. In this regard, the use of the renewable chitosan (CS) biopolymer as ion-exchange binder of the copper (Cu) electrocatalyst nanoparticles (NPs) is compared with commercial anion-exchange binders Sustainion and Fumion on the fabrication of gas diffusion electrodes (GDEs) for the electrochemical reduction of carbon dioxide (CO2R) in an alkaline medium. They were tested in membrane electrode assemblies (MEAs), where selectivity to ethylene (C2H4) increased when using the Cu:CS GDE compared to the Cu:Sustainion and Cu:Fumion GDEs, respectively, with a Faradaic efficiency (FE) of 93.7% at 10 mA cm(-2) and a cell potential of -1.9 V, with a C2H4 production rate of 420 mu mol m(-2) s(-1) for the Cu:CS GDE. Upon increasing current density to 90 mA cm(-2), however, the production rate of the Cu:CS GDE rose to 509 mu mol/m(2)s but the FE dropped to 69% due to increasing hydrogen evolution reaction (HER) competition. The control of mass transport limitations by tuning up the membrane overlayer properties in membrane coated electrodes (MCE) prepared by coating a CS-based membrane over the Cu:CS GDE enhanced its selectivity to C2H4 to a FE of 98% at 10 mA cm(-2) with negligible competing HER. The concentration of carbon monoxide was below the experimental detection limit irrespective of the current density, with no CO2 crossover to the anodic compartment. This study suggests there may be potential in sustainable alernatives to fossil-based or perfluorinated materials in ion-exchange membrane and electrode fabrication, which constitute a step forward towards decarbonization in the circular economy perspective. |
| Author Keywords |
alkaline medium; CO2 electro reduction; chitosan; copper; ethylene production |
| Index Keywords |
Index Keywords |
| Document Type |
Other |
| Open Access |
Open Access |
| Source |
Science Citation Index Expanded (SCI-EXPANDED) |
| EID |
WOS:000845523200001 |
| WoS Category |
Biochemistry & Molecular Biology; Chemistry, Physical; Engineering, Chemical; Materials Science, Multidisciplinary; Polymer Science |
| Research Area |
Biochemistry & Molecular Biology; Chemistry; Engineering; Materials Science; Polymer Science |
| PDF |
https://www.mdpi.com/2077-0375/12/8/783/pdf?version=1660560553
|