| Title |
Efficient direct membrane filtration (DMF) of municipal wastewater for carbon recovery: Application of a simple pretreatment and selection of an appropriate membrane pore size |
| ID_Doc |
15024 |
| Authors |
Sugiyama, T; Ito, Y; Hafuka, A; Kimura, K |
| Title |
Efficient direct membrane filtration (DMF) of municipal wastewater for carbon recovery: Application of a simple pretreatment and selection of an appropriate membrane pore size |
| Year |
2022 |
| Published |
|
| DOI |
10.1016/j.watres.2022.118810 |
| Abstract |
Considerable attention has been paid in recent years to the recovery and effective utilization of organic matter in municipal wastewater for the establishment of a circular economy. Direct membrane filtration (DMF) of municipal wastewater using microfiltration (MF) or ultrafiltration (UF) membranes to retain and concentrate the organic matter in municipal wastewater could be a practical option for this purpose. However, severe membrane fouling and high concentrations of organic matter remaining in the DMF permeate are concerns to be addressed. Application of a simple pretreatment using fixed biofilms was investigated to address these issues. In this study, experiments were carried out at an existing municipal wastewater treatment plant. A moving bed biofilm reactor (MBBR) process operated under a very short HRT of 1 h and DO concentration of 0.5 mg/L selectively degraded low-molecular-weight dissolved organic matter in municipal wastewater without degradation of membrane-recoverable suspended and colloidal organic matter. Application of the pretreatment did not reduce the amount of organic carbon recovered by DMF using an MF membrane (approximately 70% of the influent COD being recovered), while it dramatically mitigated the membrane fouling probably due to the alteration of characteristics of dissolved organic matter in wastewater. The pretreatment also reduced the concentration of organic matter in the DMF permeate by 41%: COD concentration in the DMF permeate was as low as 40 mg/L. With the established MBBR pretreatment, performances of MF (0.1 mu m) and UF (molecular weight cut-off: 150,000) membranes for DMF were compared in parallel. It was found that the increase of the recoverable amount of organic matter by using UF was marginal (about 5%), whereas fouling in UF was much more severe than that in MF. The severe fouling in UF was caused by inorganic colloids such as FeS that could pass through MF membranes but be retained by UF membranes. Based on the results obtained in this study, it is concluded that MF is more suitable than UF for efficient DMF. |
| Author Keywords |
Wastewater; Carbon recovery; Direct membrane filtration; MBBR; Membrane fouling; Inorganic colloid |
| Index Keywords |
Index Keywords |
| Document Type |
Other |
| Open Access |
Open Access |
| Source |
Science Citation Index Expanded (SCI-EXPANDED) |
| EID |
WOS:000856041300003 |
| WoS Category |
Engineering, Environmental; Environmental Sciences; Water Resources |
| Research Area |
Engineering; Environmental Sciences & Ecology; Water Resources |
| PDF |
http://manuscript.elsevier.com/S0043135422007631/pdf/S0043135422007631.pdf
|